PENGEMBANGAN PERANGKAT LUNAK ALAT BANTU PERANCANGAN SIKLON SEPARATOR HEMAT ENERGI
Abstrak
This paper presents an optimization technique applying the design of the cyclone separators. The results of this optimization technique were the main geometric ratio of the modiï¬ed cyclone (DOPOL), which presented in non-dimensional form, that satisï¬ed the following criteria: minimum pressure drop or maximum separation efficiency. The design procedure of the cyclone was written as the computer software, where the iterative computation design can be proceed faster. This software used the correlations of the cyclone performance obtained by the previous experimental on a modiï¬ed cyclone. The software not only could be applied for modiï¬ed cyclone design, but it also could be used for the design of the classical cyclone base on the well-known algorithm.
Referensi
Burkholtz, A. , "Droplet Separation" , VCH VmbH, 1989.
Fitradi, H.E, "Pengembangan Perangkat Lunak Desain Siklon Separator" , Tugas Akhir Teknik Mesin-ITB, 1997.
Fuchs, N. A., "The Mechanics of Aerosol" , Pergamon Press, 1964.
Kalen, B. & Zenz, F.A., "Theoritical-Empirical Approach to Saltation Velocity in Cyclone Design" , A.I.Ch.E. Symp. Series VoL 70-110.137, 1974.
Koch, W.H. & Licht, W. "New Design Approach Boosts Cyclone Efficiency" , Chemical Eng., 1977.
Kurniawan, K.P., "Pengembangan Siklon Separator Hemat Energi" , Tesis Magister, Fakultas Pasca Sarjana, Institut Teknologi Bandung, 1997
Leith, D. & Licht, W. , "Air Pollution and It's Control" , A.I.Ch.E. Symposium Series VoL68- 110.126, 1972.
Ontko, 'J.S., "Cyclone Separator Scaling Revisited" , Powder Technology Vol.87, Elsevier 1996.
Stairmand, J.C., "The Design and Performance of Cyclone Separators" , Trans. Inst. Chemical Engineers Vol.29, 1951.
Svarovsky, L. "So1id~Gas Separation" , Handbook of Powder Technology, Vol.3, Elsevier, 1981.
Stoecker, W.F., "Design of Thermal Syslems" , McGraw Hill, 1989."f
